DD5 Severe Service
Severe service applies to vehicles that average below 10.0 miles per gallon or that operate under severe conditions. Examples of Severe Service are idle time over 40%, load factor over 55%, operation on extremely poor roads or under heavy dust accumulation; constant exposure to extreme hot, cold, salt-air, or other extreme climates; frequent short-distance travel; construction-site operation; or farm operation. Only one of these conditions is necessary to categorize an application as Severe service.
Table 1, DD5: Severe Service Maintenance Intervals GHG17 with ULSD Fuel
|
GHG17 Using DFS 93K222(CK-4) or 93K223(FA-4) Approved Oils |
|||||
|---|---|---|---|---|---|
|
Lubricating Oil |
Replace every 35,000 mi (56,000 km) (1,000 hrs) (12 months)1 |
||||
|
Lubricating Oil Filter |
Replace every 35,000 mi (56,000 km) (1,000 hrs) (12 months)1 |
||||
|
Coolant - Standard Life |
Maintain every 35,000 miles (56,000 km) (1,000 hrs) (12 months)1 Replace every 300,000 miles (482,000 km) (2,000 hrs) (24 months)1 |
||||
|
Coolant - Extended Life |
Maintain every 70,000 miles (113,000 km) (1,000 hrs) (12 months)1 Replace every 600,000 miles (965,000 km) (4,000 hrs) (48 months)1 |
||||
|
Fuel Filters (frame and engine) |
Replace every 35,000 mi (56,000 km) (1,000 hrs) (12 months)1 |
||||
|
Engine Steam Clean |
At every oil change to remove particle buildup, grime, salt and normal fluid seepage, see How to Clean an Engine. |
||||
|
Valve Lash Adjustment |
Adjust every 113,000 km (70,000 miles) (2,300 hrs) (24 months)1 |
||||
|
Belts |
Inspect every 35,000 miles (56,000 km) (1,000 hrs) (12 months)1 Replace every 105,000 miles (170,000 km) (3,000 hrs) (36 months)1 |
||||
|
Air System |
Inspect every 35,000 mi (56,000 km) (1,000 hrs) (12 months)1 |
||||
|
Air Cleaner |
Refer to vehicle maintenance procedures |
||||
|
Exhaust System |
Inspect every 35,000 mi (56,000 km) (1,000 hrs) (12 months)1 |
||||
|
Aftertreatment Devices |
Inspect external hardware and connections every 6 months or at oil change intervals.1 |
||||
|
Diesel Particulate Filter2 |
A Check Engine Indicator or mileage/time intervals indicate when ash cleaning is required. Use DETROIT Diesel Corporation’s authorized DPF cleaning procedure. Failure to follow this procedure could result in engine and/or aftertreatment damage, causing degraded vehicle performance including excess fuel consumption and decreased engine life. Normal DPF ash clean interval is less than 190,000 mi (306,000 km) (6,300 hrs)1 |
||||
|
DEF Pump Filter |
Replace every 500,000 miles (805,000 km) (10,000 hrs) (3 years)1 |
||||
|
Air Compressor |
Inspect every 35,000 mi (56,000 km) (1,000 hrs) (12 months)1 |
||||
- Whichever comes first. Note: Reaching the Davco change line supersedes these intervals.
- Detroit highly recommends exchanging the DPF with a Detroit™ genuine DPF to ensure maximum life.